CPSC, Polaris Industries Announce Recall of "900 Fusion," "900 RMK" and "900 Switchback" Snowmobiles
CPSC Recall Notice
Source: U.S. Consumer Product Safety Commission (CPSC) — official agency notice for recall CPSC-3079.
Model year 2005 Polaris "900 Fusion", "900 RMK", and "900 Switchback" snowmobiles with model numbers S05PL8DSD, S05PM8DS(A)(B), S05PN8DS, S05PS8DS, S05MP8DS(A)(B)(C), S05PL8DS(A)(B)(C) are part of this recall. The snowmobile model and serial number identification decal is located on the right front side of the tunnel. The serial number is permanently stamped into the tunnel and the model number is embossed on the decal.
Corrective Action (per CPSC)
Source: U.S. Consumer Product Safety Commission (CPSC) — official agency notice for recall CPSC-3079.
Free repair. Contact your Polaris dealer to schedule an appointment to install a jumper wire and secure existing wiring harness. Polaris has notified consumers directly about this recall.
✅ What you should do
- Stop using the product if you own it.
- Check the model number, lot code, or sell-by date against the recall notice above.
- Contact Polaris Dealers Sold These Snowmobiles Nationwide, From August 2004 Through February 2005, For Between $8,882 And $10,999. or the retailer where you bought it for a refund, replacement, or repair.
- For the most current official instructions, visit the CPSC recall page.
- If you've been hurt by this product, report the incident to CPSC.
Consumer Contact (per CPSC)
Source: U.S. Consumer Product Safety Commission (CPSC) — official agency notice for recall CPSC-3079.
Call Polaris at (800) 765-2747 between 8 a.m. and 12 midnight ET everyday or log on to the company's Web site at www.polarisindustries.com
About the U.S. Consumer Product Safety Commission
The CPSC protects consumers from injuries and deaths from thousands of types of consumer products — toys, furniture, electronics, appliances, and more.
Visit CPSC.gov →📣 Report an unsafe product to the CPSC
If you own this product and experienced a defect, near-miss, or injury, file a report with the CPSC. Consumer reports are the primary signal the agency uses to identify defect patterns and trigger future recalls. Your report is free, takes about 10 minutes, and can stay anonymous to the manufacturer.
Polaris Dealers Sold These Snowmobiles Nationwide, From August 2004 Through February 2005, For Between $8,882 And $10,999. Recall FAQ
Polaris Dealers Sold These Snowmobiles Nationwide, From August 2004 Through February 2005, For Between $8,882 And $10,999. is the subject of a consumer products recall: CPSC, Polaris Industries Announce Recall of "900 Fusion," "900 RMK" and "900 Switchback" Snowmobiles. The notice was published on March 14, 2005 by the U.S. Consumer Product Safety Commission (CPSC). Approximately 11,560 units are potentially affected.